Several folks requested pictures of a pinblock separation repair, so here goes. Click on the links below for the pictures. Several show the pipe clamps in place. After applying epoxy into the crack as deep as you can get it, it seems to help to tighten each clamp and then go back and tighten them all again. Tighten all clamps several times - you will find that even though they were tight a few minutes ago, you can often keep tightening them more and closing the gap more. Keep cleaning up squeeze out as you go. Important to remember to only clamp at backposts. If you try to clamp on the spacer blocks between backpost you will only manage to bust up the back assembly pretty good - DAMHIK (it was a long time ago - and on my piano)! In past jobs on larger pianos I was able to bolt, clamp and epoxy all at the same time. On this console, I had space problems so I epoxied and clamped - let cure for 48 hours - then drilled and through bolted. You will see in two of the pictures that the nut for the center bolt was right in the middle of several tuning pins - I couldn't get a wrench on the nut with the tuning pins in place. So I had to remove them to tighten nut. A pretty acorn nut would not fit on the center bolt so I just used a plain nut. You'll also note that I had to go in on a bit of an angle on the two end bolt holes because of case clearance problems. Other than that, all is fairly self-explanatory I think. Please ask away if you have any questions. Piano tuned up real nice and I think it has decades of service left in it. Terry Farrell Photos at: https://www.moypiano.com/ptg/files/attachments/04/db/d1/21/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/04/3e/e6/c2/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/d9/42/80/f5/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/42/bb/a1/18/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/64/6b/32/73/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/19/97/03/20/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/43/86/a7/f0/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/50/7e/80/48/ attachment.jpe https://www.moypiano.com/ptg/files/attachments/5f/f9/d4/79/ attachment.jpe Alternate: http://tinyurl.com/t9j7 http://tinyurl.com/t9je http://tinyurl.com/t9jm http://tinyurl.com/t9jr http://tinyurl.com/t9jw http://tinyurl.com/t9jz http://tinyurl.com/t9k1 http://tinyurl.com/t9k5 http://tinyurl.com/t9k8
This PTG archive page provided courtesy of Moy Piano Service, LLC